產品品牌：海韻牌

產品型號：BT-4015

產地：湖南長沙

海韻牌BT-4015型普通早強減水劑Chaton brand BT - 4015 general type early strength water-reducing agent執行標準：GB/8076-2003Execution standard: GB / 8076-2003一、用途及特點A, use and features　　本劑有一定的早強、減水、增強作用，屬自然養護型外加劑。本劑一般用于磚混結構建筑物所用的混凝土。摻本劑的混凝土在常溫下成型5d后可以達到設計標號的75%以上。使用摻加本劑的混凝土澆筑圈梁、構造柱、陽臺、雨蓬等構件強度增長較快，后期強度比不摻本劑的混凝土高。使用本劑既能縮短工期，又能保證工程質量。本劑適用于常溫、低溫和正負溫度交替（日最低溫度不低于-5℃）環境中施工的有早強要求的普通混凝土、鋼筋混凝土和預應力混凝土工程?！　his agent has certain early strength, decrease water, strengthen the function of natural conservation type admixtures. This agent commonly used for brick and concrete structure building of concrete used. The agent of concrete admixture at room temperature after forming 5d can achieve design of premium 75%. Use by adding this agent of concrete pouring struts, constructional column, balcony, rain loose component such strength is growing faster than not, post strength of concrete admixture this agent high. Use this agent can not only shorten the construction period, and guarantee the quality of the project. This agent for interesting, low and plus or minus the minimum temperature, temperature is alternant (not less than -5℃) in the environment construction have early strength requirement of common concrete and reinforced concrete and prestressed concrete engineering.二、執行標準：GB 8076-2003Second, executive standard GB 8076-2003三、用量與用法Three, dosage and usage1、摻量：水泥質量的1.5%。每100kg水泥加本劑1小包（1.5kg）。1, dosage: cement quality 1.5%. Every 100kg cement with this agent 1 packet (1.5 kg).2、早強減水劑混凝土的攪拌和振搗方法，可與不摻外加劑的混凝土相同，粉劑加入攪拌機時，應先與水泥、骨料干拌后再加水，攪拌時間不得少于3min。2, early strength of concrete mixing and water-reducing agent ofnon-vibrating methods, but not mixed with the concrete admixtures same, powder join mixer, should first and cement, aggregate dry mix water again after, whisking time shall not be less than 3min.3、采用自然養護時，應用塑料薄膜覆蓋；低溫時，應用保溫材料覆蓋。不能用于蒸養混凝土。3, using natural when maintaining, plastic mulch, Low temperatures, the application of heat preservation material covered. Cannot be used to evaporate raise concrete.四、貯運及包裝Four, shipping and packaging1、塑料袋小包裝每包1.5kg，編織袋集裝大包裝。1 small packaging, plastic bags per pack 1.5 kg, woven containers big packing.2、本劑為粉狀。搬運時嚴防破損。貯存時應防潮。如有受潮結塊，應粉碎并通過0.63mm的篩后方可使用。2, the agent for powder. When carrying takes strictprecautions against breakage. When storing should be moistureproof. If any damp agglomerate, shall shatter and through the average mm sieve rear can use.3、貯存期：3年。3, storage period: three years.

編號	摻量%	用水量(g)	塌落度(mm)	減水率(%)	抗壓強度（MPa）/抗壓強度比（%）
					1d	3d	7d	28d
0708基準	——	2730	81	——	7.6	13.46	18.53	24.7
MNC-A 1	2.5	2100	79	23.1	26.29/345.9	35.07/260.5	39.74/214.5	45.92/185.9
MNC-A 3	2.0	2150	86	21.2	23.44/308.4	33.41/248.2	37.84/204.2	39.98/161.9
MNC-A 5	1.5	2270	76	16.8	16.3/214.6	25.89/192.3	29.69/160.2	35.23/142.6

　　早強減水劑是以 β- 萘磺酸鹽甲醛縮合物為主要成份，并復合有增強組份的高效早強減水劑，它具有對水泥品種適應性好，引氣量少等特點，減水增強效果顯著，早強作用尤為明顯，能提高混凝土抗凍性、抗?jié)B性和耐久性。產品符合混凝土外加劑國家標準?！　arly strength water-reducing agent inβ- beta naphthalene sulfonates formaldehyde condensation content is the main ingredients, and composite has enhanced the efficient components of the early strength jianshuiji, it has good adaptability to cement, lead low gas wait for a characteristic, decrease water enhancement effect significantly, early strength effect is particularly obvious, can improve the concrete frost resistance, penetration-proof quality and durability. Products comply with concrete admixtures national standards.用途及摻量：Usage and dosage:　　早強減水劑對鋼筋無銹蝕作用，無毒、無污染，可應用于公路、橋染、港口碼頭，工業及民用建筑的鋼筋混凝土或預應力混凝土結構，蒸養及自然養護的預制構件等，也可用于氣溫不低于 - 5 ℃ 時的冬期施工。它的推薦量為水泥重量的 1.5% ，減水率 15% ， 3d 強度提高 100% ， 7d 強度提高 70% ， 28d 強度提高 40% ，混凝土坍落度可提高 2 ～ 3 倍，或節約水泥 10 ～ 15% 。　　Early strength of reinforced jianshuiji no rust role, non-toxic, non-polluting, can be used in highway and bridge dye, harbor, wharf, industrial and civil building of reinforced concrete or prestressed concrete structure, steaming raise and natural conservation of prefabricated components etc, also can be used for temperature not less than -5℃ when the winter of construction. It is the recommended amount of weight 1.5% of cement, decrease water rate of 15%, 3d strength is increased by 100%, 7d strength improved 70%, 28d strength increased 40%, concrete slump can raise 2～ 3 times, or save cement 10～ 15 percent.使用方法：Method of use:1 、高效早強減水劑為粉劑，使用時，可直接與水泥集料一起投入攪拌機進行攪拌。1, efficient early strength jianshuiji for powder, when using, which can be directly and cement aggregate together into blender for mixing.2 、產品應存放于干燥處，若產品受潮結塊，應用水化開后使用。2, the product should be stored in a dry place, if the product damp agglomerate, application hydration open after use.